饲料称量包装的准确与否将直接影响到企业的信誉和经济效益。过去采用机械称量、人工装袋，劳动强度大、速度慢、精度低。KULICKE & SOFFA  05100-4200-000-45近几年，采用电子称量装置虽然可使其静态称量精度大大提高，但在饲料加工连续生产过程中，其动态精度仍不能保证。因此，在快速自动称量中如何提高动态称量精度，一直是饲料加工企业急需解决的难题。
本文是作者在研制饲料自动化生产设备中，为了与配料过程相协调，实现饲料生产的全部自动化，应用PLC作为动态称量包装测控设备，在硬件和软件设计中采用了一些措施和动态控制方法，较好地兼顾了称量速度与精度的矛盾，实现了饲料连续生产中动态称重计量的精度。
一、KULICKE & SOFFA  05100-4200-000-45系统工作原理
用称重传感器、放大器和PLC组成测控系统来完成饲料的称重、计量、包装的生产工艺过程，该系统以PLC为核心，配以称重传感器、放大器、各种电动执行器和机械装置，实现饲料的动态在线称重计量和包装工作。
称斗的上方是成品仓，该仓中的原料是来至饲料混合工序生产的饲料散状成品料。成品仓下是一台电动机驱动的螺旋进料装置，启动电动机，则该成品仓中的粉状饲料就随着传输绞笼的旋转而进入称斗中称量。称斗上装有三个S梁式应变式拉力传感器，称斗的重量信号直接由该传感器组转换成与之对应的电压信号，经放大器把该电压信号放大后送入PLC中进行数据处理，当达到预定值时，PLC控制停止下料，然后PLC控制开称斗门，并控制打包机自动装袋后由传送带送出。于是，就完成了饲料称量打包的自动化过程。
二、KULICKE & SOFFA  05100-4200-000-45提高动态称重精度的硬件措施
该系统用三个拉力传感器将饲料重量W变换为成线性关系的电压信号Ux，并通过两级放大器进行放大。Un表示等效到放大器输入端的噪声和干扰电压，ΔUi表示等效到输入端的漂移电压。设两级放大器的放大倍数为A，则Uo=A(Ux+Un+ΔUi)=AUx+AUn+A·ΔUi式中的第2项主要影响灵敏度，第三项主要影响系统的精度。
1、影响传感器的因素及解决办法
传感器输出信号的稳定性除决定传感器本身的性能外，还与供电电源和传感器的安装有密切关系。本系统采用UH61-100u型三只称重传感器，每只传感器单独供电，通过调节其桥路电压使三只传感器的输出灵敏度K相同，三只传感器串联输出的电压为Ux=K(E1+E2+E3)。为了提高每个传感器供桥电源的稳定性采用二次稳压，并对元器件进行老化、测试后进行选配，特别是对基准稳压管2DW233的老化处理和时漂测试，选择时漂小的通过调节其工作电流使其工作在接近零温度系数（<2ppm/℃）下，使整个传感器电源的温度稳定性优于10ppm/℃。三只拉力传感器安装在称斗和称架之间。如果传感器承受的重量与传感器轴线存有ɑ角，则将产生横向分力而引入误差ΔW=W-Wcosɑ.这对于每次称重25Kg，在称斗皮重为100Kg的情况下，即三只100Kg的传感器实际荷重为125Kg。当ɑ=4°时，称重误差就为0.43Kg。因此，安装传感器时应设法确保传感器都能垂直受力。
2、KULICKE & SOFFA  05100-4200-000-45影响系统灵敏度的因素及解决办法
影响系统灵敏度的主要因素是检测电路的内部噪声和外部干扰电压Un，它与放大器所工作的频带相关。在研制中，通过选择低噪声器件，在满足采集速度所需足够宽的频带的前提下，通过选配电阻来提高放大电路本身的共模抑制能力，整个检测系统采用双层屏蔽，采样时间选为工频周期整数倍等项措施，使整个系统获得了能分辨5g重量的灵敏度。
3、影响准确度的主要因素及解决办法
影响准确度的主要因素是整个检测系统的非线性和漂移ΔUi。其中系统的非线性，在选配元器件校正的基础上，采用了软件修正；而对于随温度和时间产生的漂移电压ΔUi，主要采用元器件的老化、测试与分选工艺，筛选掉时漂大的，然后选配温度系数进行补偿，使整个系统的静态精度达到了0.07%，为实现动态称量精度奠定了基础。
三、KULICKE & SOFFA  05100-4200-000-45提高动态称重精度的软件措施
影响动态称重精度的主要因素是被称物料的比重、流量和落差的大小，它是由成品料仓的压力和PLC所控制的进料驱动装置产生的。因此，改进控制思路，借鉴静态称量精度高的特点是提高动态计量精度的关键。为此，我们选用双速变径变距螺旋加料机，采用"先快后慢，最后点动"的控制下料方式，如图2所示。图中：Wx0为称量前PLC所采集的称斗皮重；由此PLC按照每包计量净重量的90%、95%和100%算出快速下料的终了值Wx1、慢速下料终了值Wx2和称量终了值Wx。其控制过程可以这样简单说明：在下料开始一段时间，PLC控制绞笼电动机快速下料，当检测达到快速下料的终了值Wx1时，PLC控制绞笼电动机开始慢速下料；当检测达到慢速下料的终了值Wx2时，PLC关闭绞笼电动机后采用"点动"下料，当达到或接近期望值Wx时为止。
按照上述思路，通过编写全动态控制加料的快慢、速加料和点动下料的软件模块；以及为消除空中落料对称量精度的影响，所编写的自动寻找提前停机量的软件模块等软件措施。该系统使用一年来，经计量部门两次测试，整个系统动态计量准确度优于0.2%。
四、KULICKE & SOFFA  05100-4200-000-45结论
采用PLC控制进行饲料称重包装，具有结构简单、计量准确、工作可靠，较好的兼顾了动态称重计量的精度和速度，满足了在线快速动态重量计量的要求，对水泥、食盐、面粉等的称重包装有借鉴作用和推广价值。

----商务热线---厦门兴锐达自动化设备有限公司
联系人：王文光
++QQ:2851759104
手机：15359273780
电话：0592-5580707 400-855-5103转001
传真：0592-5361289
邮箱：2851759103@qq.com
网址：http://www.xmxrdauto.com

KULICKE & SOFFA  05100-4200-000-45

KULICKE & SOFFA  01483-4203-000-08

KULICKE & SOFFA  00797-4235-001-02

Kulicke & Soffa N08001-4154

KULICKE & SOFFA  00835-4580-000-71

KULICKE & SOFFA  8002-4104

Details about MOTORCRAFT JC-463-LA NSPP JC463LA
DODGE 124167 NSFP 124167
Details about HYSTER 118671 NSFP 118671
MITSUBISHI AJ1-LP1 USPP AJ1LP1
RELIANCE ELECTRIC 0-51439-1 USPP 0514391
Details about ITE SIEMENS 5SX4216-6 USPP 5SX42166
Details about SIEMENS 6ES7-318-2AJ00-0AB0 NSFP 6ES73182AJ000AB0
Details about SIEMENS 6ES7-652-0XX01-1XF1 NSFP 6ES76520XX011XF1
Details about FURNAS ELECTRIC CO MT2000I NSFP MT2000I
Details about YALE 505970533 NSPP 505970533
Details about ENERGIZER 03-2023 NSPP 032023
SICK OPTIC ELECTRONIC WL12-2P730 USPP WL122P730
Details about DONALDSON P164378 NSFP P164378
Details about TEXAS INSTRUMENTS PLC 565-2122 USPP 5652122
Details about FURNAS ELECTRIC CO 14BF-32BA USPP 14BF32BA
Details about RCA SK9455A NSPP SK9455A
Details about ITE SIEMENS EF3-A025 NSFP EF3A025
Details about STANDARD MOTOR PARTS DR459 NSFP DR459
Details about POTTER & BRUMFIELD 27E128 FNFP 27E128
Details about 2001 Motoman UP6 XRC robotic mig welding cell currently in Adelaide robot
Details about YASKAWA ELECTRIC SGDB-44ADS USPP SGDB44ADS
WESTINGHOUSE QNPAL2100 USPP QNPAL2100
Details about SKF 18968 NSFP 18968
MITSUBISHI FA-TH1YTL11S USPP FATH1YTL11S
Details about VG POWER AB K7000-009 USPP K7000009
Details about GENERAL INSTRUMENT KBU8G FNFP KBU8G
Details about Modicon AS-P120-000 AC POWER CONVERTER / POWER SUPPLY
Details about Harting HAN 3 Plugs multipin connectors
Verity FL2002 Endpoint 1005337AT AMAT 1010-00212 SD1024D 1005234AT 1400-00205
Details about MICROSWITCH FE7D-RR7 USPP FE7DRR7
Details about PYROTRONICS HTRI-R NSPP HTRIR
Details about FURNAS ELECTRIC CO SMF-FG1 USPP SMFFG1
Details about Telephone or PLC main distribution frame rack Adelaide delivery vert DIN rails
Details about NOK VG-S250 USPP VGS250
MITSUBISHI MELSEC F-0 NEW
WESTINGHOUSE 5A26482G01 USPP 5A26482G01
Details about DALSA PB-CX/L145D-00000 USPP PBCXL145D00000
Details about POWER ONE HN24-3.6-A USPP HN2436A
Details about WIX FILTERS 46174 USPP 46174
DODGE 1-A3.8-B4.2 NSPP 1A38B42
Details about COMTRONIC WSCL-3 FNFP WSCL3
DODGE F2B-SC-107 NSPP F2BSC107
Details about SAUER DANFOSS CP332-3-B-34-4.0 USPP CP3323B3440
Mitsubishi AJFBTA-1DTE PLC input output module NEW CC link
Details about FURNAS ELECTRIC CO 3TF4-822-0DB4 USPP 3TF48220DB4
YASKAWA YASNAC OPTCODER MGZ-10B MGZ10B
Details about WAGO 231-308/026-000 USPP 231308026000
Details about  SIEMENS SITRANS P-7MF4033-1FA10-1AA1-Z pressure transmitter 0.16 to 160 bar
Details about RADWELL VERIFIED SUBSTITUTE 800TN319RSUB FNFP 800TN319RSUB
Details about YALE 580067372 USPP 580067372
Details about ITE SIEMENS A203C-110/120V USPP A203C110120V
Details about POTTER & BRUMFIELD T9AV5D12-22 FNFP T9AV5D1222
WESTINGHOUSE HFD-3020L USPP HFD3020L
Details about ITE SIEMENS G30T17 NSFP G30T17
Details about FURNAS ELECTRIC CO 52SW2HAB NSFP 52SW2HAB
Details about POWER ONE RS-PSU-450-ACHE USPP RSPSU450ACHE
Details about WATLOW SD6L-HJUE-AARG USPP SD6LHJUEAARG
WESTINGHOUSE CB3015FB USPP CB3015FB
Details about GATES AX39 NSFP AX39
Details about INA KBS2558PP NSFP KBS2558PP
SICK OPTIC ELECTRONIC C4MT-09034ABB00AA0 USPP C4MT09034ABB00AA
Mitsubishi FXN-1MT-ESS/UL, New, FXN1MTESSUL, Fast
RELIANCE ELECTRIC 0643-01-032 USPP 064301032
Details about SIEMENS 6FX20013GB02 USPP 6FX20013GB02
Details about ALLEN BRADLEY 800T-A2 NSPP 800TA2
Details about FURNAS ELECTRIC CO 52NL26 NSPP 52NL26
Details about CHICAGO RAWHIDE 99172 USPP 99172
Details about NTN BEARING 7305-B NSFP 7305B
Details about FSP FSP30060PLNR FNFP FSP30060PLNR
Details about CBI QZ-3-13-D-9-10 USPP QZ313D910
AMAT 300mm Process RTP Chamber for parts
Details about NUTRON BV-6-V USPP BV6V
WESTINGHOUSE 204P021H01 USPP 204P021H01
Details about BILZ UTS-93255 NSFP UTS93255
Details about Nikon microscope rings set of 3
RELIANCE ELECTRIC 0-54346 NSFP 054346
Details about TELE RADIO 460-464AL USPP 460464AL
Details about LIMITRON FNQ-R-7 USPP FNQR7
WESTINGHOUSE FB2125 USPP FB2125
Details about Spirax Sarco Spiral Wound Gasket SS / graphite 0.75 inch for TD 3-4 /TD 3-4LC
Details about SIEMENS 6FX1-112-1AC00 USPP 6FX11121AC00
SICK OPTIC ELECTRONIC FX3-XTIO84002 NSFP FX3XTIO84002
Details about HYSTER HY381355 NSPP HY381355
Details about FURNAS ELECTRIC CO 3RK1304-5KS40-4AA0 NSFP 3RK13045KS404AA0
SICK OPTIC ELECTRONIC WT18-P410 USPP WT18P410
QCI SilverMAX S34H-1-E-01 S34H1E01 Servomotor
Details about  Fanuc RJ-21 PSU Power Supply Board A16B-1212-0871/07A
Details about ITE SIEMENS GB202 NSPP GB202
Details about MOORE PRODUCTS 16353-52 NSFP 1635352
Details about 12ch 12 Way 3 Relay Switch array 3 phase Power Distribution Unit
DODGE FC-SC-107 NSFP FCSC107
Details about BELL & GOSSETT 123-204 USPP 123204
Moeller SYSTM-STR-10 Non-Combo Non-Reversing System Starter 3Ph 575V 1NO ! RFB!
Details about TELEMECANIQUE XES-P2051 USPP XESP2051
Details about WATLOW 965A-3CD1-0000 NSPP 965A3CD10000
Details about NATIONAL SEMICONDUCTOR IC14C89AN FNFP IC14C89AN
Details about SPANG HB2G5-B-2-111810 USPP HB2G5B2111810
WESTINGHOUSE 313C590G10 NSFP 313C590G10
Details about TELECT F12-SSG-M002-0 NSFP F12SSGM0020
WESTINGHOUSE B100S0B USPP B100S0B
Details about WIX FILTERS 33394 NSFP 33394
Details about DWYER 3015 NSFP 3015
DODGE MR94651L1 NSFP MR94651L1
Details about LANDIS & GYR SSC81U NSFP SSC81U
Details about GE FANUC IC693ALG392 USPP IC693ALG392
Details about Rosemount Magnetic Flowmeter Mag Flow magflow tube 8705NTA180 C104 DN 450 18"
DODGE F4B-E-208R NSFP F4BE208R
Details about TELEMECANIQUE XCK-P118H7 NSPP XCKP118H7
Details about TEXAS MICROSYSTEM IPC-15RM NSFP IPC15RM
WESTINGHOUSE FDB2030M03 USPP FDB2030M03
Details about FURNAS ELECTRIC CO 52AEDB NSFP 52AEDB
DODGE FC-DLNP-40M-CR NSPP FCDLNP40MCR
Details about RELIANCE ELECTRIC 411609-21B NSPP 41160921B
Details about WARNER ELECTRIC 6001-448-004 FNFP 6001448004
Details about MCQUAY PERFEX 382557B-00 USPP 382557B00
RELIANCE ELECTRIC S-67118-B USPP S67118B
WESTINGHOUSE MSH-0.61A NSFP MSH061A
Mitsubishi Melsec AD1 PLC High Speed Counter Module NEW
Details about SMC VP342-5D-02A NSFP VP3425D02A
Details about BALLUFF BES-516-207-BO-E-03 FNFP BES516207BOE03
Omron E3X-NA41 PhotoElectric Switch
Details about DODGE 1610-5/8 NSFP 161058
Details about Large Display Meter RPM in metal angle enclosure ex tafe
Details about SIEMENS 5SY6106-6 NSFP 5SY61066
Details about REXNORD ES3-R NSPP ES3R
Details about WIX FILTERS 33049 FNFP 33049
Details about THOMAS & BETTS 3303 NSPP 3303
JSR SONIX Ultrasonics DPR500-S DUAL PULSER / RECEIVER
WESTINGHOUSE T730045504 USPP T730045504
Details about FURNAS ELECTRIC CO 31-20275-02 NSFP 312027502
Details about MILLTRONICS PBD-92712000 USPP PBD92712000
DODGE FB-DL-012 NSPP FBDL012
Details about STAEFA CONTROL SYS 091-60200-40 USPP 0916020040
DODGE HS2-SFXT-517 NSFP HS2SFXT517
RELIANCE ELECTRIC FPS-80 USPP FPS80
SICK OPTIC ELECTRONIC WS27-2D450S05 NSFP WS272D450S05
Details about OMEGA ENGINEERING DP24-E NSPP DP24E
Details about FURNAS ELECTRIC CO 3RK1903-0CD00 NSFP 3RK19030CD00
WESTINGHOUSE 422D949G39G NSPP 422D949G39G
SICK OPTIC ELECTRONIC WL45-P260 USPP WL45P260
Applied Materials Metal Etch 0010-70078 Tray, Assy. 200 MM 29 slot (USED) AMAT
WESTINGHOUSE MS-H2.3A USPP MSH23A
Details about BENTLY NEVADA 3300/50 TACHOMETER BUFFERED TRANSDUCERS, 84133-01, NEW
Details about ITE SIEMENS G30T48 USPP G30T48
Details about ITE SIEMENS JKF400 USPP JKF400
FANAL DSL10-40-120V NSFP DSL1040120V
Details about BRONKHORST F-202AC-FDC-44V NSFP F202ACFDC44V
SICK OPTIC ELECTRONIC KP-DB15/2-DB15-3M-EE USPP KPDB152DB153MEE
Details about FURNAS ELECTRIC CO 49EC14GB140807R NSFP 49EC14GB140807R
Details about TB WOODS 13.6X2B-SK USPP 136X2BSK
WESTINGHOUSE BA250 NSPP BA250
Details about HARWAL 14X28X07 NSPP 14X28X07
WESTINGHOUSE 100P475H01 USPP 100P475H01
Details about DONALDSON P558615 NSPP P558615
Details about IFM SFD10ADB/US FNFP SFD10ADBUS
Details about KLEP Glass Lined Teflon Diaphragm Valve 1" inch 25mm DN 25 NEW
WESTINGHOUSE S-844299 USPP S844299
Details about HVAC sound attenuator silencer noise control muffler 640mm ID 795
Details about WIX FILTERS 51348 NSFP 51348
RELIANCE ELECTRIC 701819-201AW USPP 701819201AW
Mitsubishi Melsec A1SJHCPU A1SX1 A1SY10 A1SDP-S PLC Unit *Fully Tested*
Details about ITE SIEMENS 5SY4-316-7 USPP 5SY43167
Details about FURNAS ELECTRIC CO 52SB2BAB FNFP 52SB2BAB
Details about APPLETON RB10075 NSPP RB10075
DODGE 031419 NSFP 031419
DODGE 6052409 NSFP 6052409
Details about ITE SIEMENS EQP3150 USPP EQP3150
Details about RKC PB-6B1C-M USPP PB6B1CM
Details about TELEMECANIQUE LC2-D4011F7 USPP LC2D4011F7
Details about STOCKHAM B-16-1-1/4 USPP B16114
Details about SIEMENS 6FX1-121-8BA03 USPP 6FX11218BA03
RELIANCE ELECTRIC 0-56917-210BA USPP 056917210BA
SICK OPTIC ELECTRONIC WTB12-3P2411 USPP WTB123P2411
Details about BENTLY NEVADA 3300 XL 8MM/330130-080-00-00 NEW
RELIANCE ELECTRIC 22492-29T USPP 2249229T
Details about FURNAS ELECTRIC CO 3RT1033-1AK60 FNFP 3RT10331AK60
Details about GENERAL ELECTRIC CR106D000BWA USPP CR106D000BWA
Details about CATERPILLAR 119-4740 NSFP 1194740
Details about ASCO USF8257A001 NSPP USF8257A001
Details about VERIS H8041-0800-3 USPP H804108003
Details about WIX FILTERS 33358 NSFP 33358
Details about FURNAS ELECTRIC CO 50D26699007 NSPP 50D26699007